Article

Vancouver firm harvests wastewater systems for profit

2 198 Projects

by Ian Harvey

It wasn't so long ago wastewater treatment facilities were just plain old sewage treatment plants. Today, the nomenclature is shifting again as municipalities latch on to innovative technologies to coax a revenue stream out of what has traditionally been a cost centre.
Vancouver firm harvests wastewater systems for profit

Ostara, a Vancouver-based maker of technology to extract phosphorous and nitrogen from the wastewater stream and to create fertilizer pellets, is at the forefront of that wave.

"There's a very wide industry trend, whereas people viewed wastewater plants as there to control pollutions, which of course is important, now we see them acting as a resource recovery centre," says Matt Kuzma, vice-president of nutrient recovery solutions for Ostara. "It was sewage, then wastewater, now they are water resource reclamation centres and extracting viable economic resources. It's bigger now. It's about water, energy and resources."

Since the dawn of civilization, dealing with effluent has always been a collective challenge. Between them, people and agricultural animals produce waste that often runs off into waterways where the embedded components cause problems if left unchecked.

Nutrient pollution is one of the biggest environmental challenges.

While they are necessary to aquatic ecosystems, once levels start to grow past normal, problems result.

Algae blooms uncontrollably, Ostara explains, decreasing oxygen levels for the other organisms and threatening their survival. Nitrogen turns to ammonia and if it pollutes drinking water causes health problems in humans.

Ostara says there are more than "400 dead zones around the world, with one of the largest in the Gulf of Mexico fed by runoff from the Mississippi River, which in turn is fed by runoff from the massive river basin network that feeds into it and stretches broadly across the U.S. heartland and all the way to the north."

However, phosphates and nitrogen are valuable commodities and instead of literally flushing them down the waterways, best practices call for their extraction, processing and sale.

The trick, of course, is to create a process at sufficient scale to be commercially viable and that's where Ostara comes in with its Pearl system producing Crystal Green fertilizer.

The concept of extracting phosphates and nitrogen from water has been around for decades, but it wasn't until about 2000 that a viable, scalable process was developed at the University of British Columbia.

Ostara was founded in 2005, licensed that process and set to work designing a commercial scale system. The first installation was a pilot at the Edmonton EPCOR waste treatment plant in 2008. In 2014 the company signed a deal to bring full-scale installation to the Clover Bar plant to help clean up the effluent pollution in the North Saskatchewan River.

Ostara has grown rapidly since that time and has a global profile with 14 plants in operation across Canada, the U.S and Europe.

Boosting growth has been a "perfect storm" says Kuzma.

"There is growing awareness about nutrient pollution and a desire to do something about it. At the same time in Canada, the last open pit phosphorous mine near Kapuskasing, Ont. closed about five years ago. It's all coming from Morocco now."

With a local demand for fertilizer, Ostara's finished products are a natural match.

"It really is a win-win," says Kuzma.

Ostara's technology is based on its Pearl fluidized bed reactor which prompts the nutrients in the stream to crystalize and grow into pure fertilizer granules. At a specific size they are harvested, dried and packaged for distribution.

Ostara says the Pearl process removes up to 85 per cent of phosphorous and 15 per cent of nitrogen while also triggering a 25 per cent reduction in biosolids production, with a four per cent improvement in biosolids dewatering.

Payback on investment can be in as little as three to five years, says Kuzma, though it varies from jurisdiction to jurisdiction.

"In some areas there are tax incentives and other incentives which will offset the costs and increase the time for ROI," he says.

Despite a string of successes, Kuzma says the wastewater treatment sector tends to be conservative and resistant to early adoption of ideas.

However, he adds, the Prairie provinces have been forward thinking in moving towards nutrient capture and fertilizer creation partly perhaps because there's a ready market for the product and partly because there's a heightened awareness of nutrient pollution in the agriculture sector.

The cost isn't out of line, he insists. Projects start in the $2- to $3-million range and go up. The world's largest full treatment plant, the Stickney Water Reclamation Plant in Chicago, which has a wet weather capacity of 5.3-million cubic metres of flow a day, has a unit which costs $30 million.

While the fertilizer is a revenue stream, there's a cost in manufacturing, harvesting and distributing it, Kuzma notes, but there's a steady margin if it's managed well.

2 comments

  • # 1

    Luca Vincent

    Sadly this process still does not "deal" with the many known toxin in all biosolids procucts. Prions, Superbugs, nanomaterials, microplastics, fire retardants, pharmacuticals etc will all still be present in the "fertilizer" It is so important to remember that sewer sludge aka biosolids is NOT just poop - it is a concentration of all domestic and industrial pollutants that go down drains and sewers. It has some good stuff in it, which plants can use, but a huge load of thousands of other contaminants.  Please read what independent scientists have to say on this issue -
    Dr. Caroline Snyder - "Land-applied municipal sewage sludge (biosolids) is a highly complex and unpredictable mixture of biological and chemical pollutants. Biosolids generated in our large industrialized urban centers is very likely the most pollutant- rich waste mixture of the 21st century."
    And see this link for a great overview of the issues - http://bit.ly/2kehQlP by Dr. Thomas Maler
    Scientists against land dispersed "biosolids"
    Canadian- http://bit.ly/1sb2qOP
    UK- http://www.wte-ltd.co.uk/sewage_sludge_biosolids.html
    US- http://pubs.acs.org/doi/full/10.1021/acs.est.5b01931
  • # 2

    Matt Kuzma

    In response to the previous comment, it’s important to clarify critical distinctions between biosolids and Ostara-produced fertilizer products. Crystal Green®, the registered fertilizer produced by Ostara, should not be confused with biosolids-derived fertilizers. In the Ostara process, nutrients such as phosphorus and nitrogen are recovered through crystallization from liquid wastewater streams. Uniquely, the crystallization and extraction process leaves behind any potentially harmful contaminants. As a result, the resulting fertilizer is 99.6% pure and cannot be compared to biosolids products.

    All Crystal Green undergoes a rigorous quality control process including analysis of physical attributes (size, hardness, color, shape), nutrients (N-P-K and Mg), heavy metals, and pathogens/indicator organisms to confirm compliance with applicable regulations for the protection of human health. Further, metal concentrations in Crystal Green are consistently well below regulatory limits for commercial fertilizers, and in fact much lower than levels in common phosphate rock derived fertilizers. Testament to the purity of Crystal Green is further demonstrated through use by British Columbia Fisheries to enrich nutrient-poor streams and enhance salmon populations (the nutrients emulate the dying salmon which feed the salmon fry). For agricultural/horticulture use, Ostara maintains state-by-state registration of Crystal Green in the US, Canada, EU, Taiwan and Puerto Rico.

Leave a comment

Or register to be able to comment.

Copyright ConstructConnect TM. All rights reserved. "ConstructConnect" is a dba for CMD Holdings.
The following rules apply to the use of this site:
Terms of Use and Privacy Statement